#1
|
||||
|
||||
Pro and Con of multiple heaters in one tank
I keep hearing people suggesting multiple, small heaters in a tank to minimize the impact of heater malfunction. Well, it may slow down your temperature going up in the event of one or more heaters malfunction. BUT, with three heaters in your tank running parallel, now you have three times the chance of getting a malfunction heater.
It may be a better idea to hook your heater to a temperature controller. If the tank temperature hitting a set point, you can instruct the controller to shut down the heater. Then again, I haven't seen a stand-alone heater controller for water. Most aqua controllers are expensive due to all-in-one design. If someone can design a heater controller, I don't think it will cost more than two heaters. Or can it? hint, hint... I don't know. I am just throwing ideas for discussion here. Thanks for your time. George |
#2
|
|||||
|
|||||
Pro and Con of multiple heaters in one tank
Basically what you're say is that you could have a backup thermostat in case your heaters' internal thermostat goes nutty? That would be pretty good idea if one could get it to work.
|
#3
|
|||||
|
|||||
Pro and Con of multiple heaters in one tank
I am looking into trying a safty shut off by using this senser in conjumction with my X-10 controler. this would basicly kill the power to the heater if it hits a preset temp. I am also looking at a reversal also by having a second heater that is always off and willcome on if the tank temp falls below a preset temp.
Steve |
#4
|
|||||
|
|||||
Pro and Con of multiple heaters in one tank
This is actually a pretty cool subject. I would buy one if it was available. We have all heard nightmare stories from some of you on the board about stupid heaters getting stuck on or off. I wish an Aquarium company would get off there butts and make something like you say, Or get someone ingenious enough to make one... hint, hint Steve :D
What makes me mad is how cheap heaters are, compaired to all other equipment in reef keeping and I am getting really worried. I run a single Ebo Jager 250 watt :mad: I only have one softy coral so far, and look at me, Im panicking! :rolleyes: [ 10 April 2002, 11:48: Message edited by: Jack ] |
#5
|
|||||
|
|||||
Pro and Con of multiple heaters in one tank
Hi, cool topic, I don't really have anything to add to the controls side of the conversation, but ...
BUT, with three heaters in your tank running parallel, now you have three times the chance of getting a malfunction heater. 'tis true, but I think what is important to realize is that if any ONE heater fails, it is not going to do any damage (or at least "not as much"). So, the risk of a failure is more, but the risk of potential damage is mitigated. So goes the theory, anyways. Unfortunately there is never any way to make the risk an absolute zero, it's all in the way we play the risk management game. But that said, I agree that it would be VERY nice to see an inexpensive solution that could be applied to heater control without a multiple-hundred-dollar investment. |
#6
|
|||||
|
|||||
Pro and Con of multiple heaters in one tank
Jack,
I am in the process of building a PIC(Programmable Interrupt Controller) based Control system for home use. Once I write my calculus midterm this week I will be prototyping it to see how things go. If that goes well I will try making one. I am planning on using this summer to get this and a couple other projects going. It will measure the tank temp and then control; fans(variable speed deepndant on tank temp), lighting, heaters and if I can get one large enough a pelltier device to do cooling as well as heating. So there will be some available in the future. I don't have a cost yet. It will be cheaper than others out there I hope. But very small quantities produced. Just so ya know. |
#7
|
|||||
|
|||||
Pro and Con of multiple heaters in one tank
I am eagerly awaiting Darren's temp controller but in the meantime if you can't wait Ranco make a temperature control. It's available through Ackland-Grainger and, if memory serves me, is in the neighbourhood of $100Cdn. Reviews of this product were predominantly positive. A search on Reefcentral will give you more information.
|
#8
|
|||||
|
|||||
Pro and Con of multiple heaters in one tank
Quote:
Multiple heaters: Great safety net if one fails and shuts down Useless if one fails and stays on |
#9
|
|||||
|
|||||
Pro and Con of multiple heaters in one tank
Quote:
Steve |
#10
|
||||
|
||||
Pro and Con of multiple heaters in one tank
"Multiple heaters:
Great safety net if one fails and shuts down Useless if one fails and stays on " The point is, one of them is far too weak to ever over heat your tank. Get it? If one is stuck on, the others will simply not turn on as often. The only problem with the multiple heater setup is you actually have to check the heaters from time to time to make sure they're functioning. You might not even know if one is stuck on or stuck off because the temperature of the tank might not fluctuate much. Seems to me, an expensive controller is just back to having all of your eggs in one basket again. If the controller described above fails while you're away, then you have no heat control, no lights, no fans, etc. Right? |